Efficacy of Manufacturer Recommended Microwave Time Against Listeria monocytogenes in Ready-to-Eat Chicken Products
DOI:
https://doi.org/10.3923/ijps.2012.177.180Keywords:
Listeria monocytogenes, microwave, ready-to-eat chickenAbstract
This study evaluated the effect of manufacturer-recommended microwave times on Listeria monocytogenes in Ready-to-Eat (RTE) poultry products. Three chicken products including battered and breaded chicken patties, fully cooked chicken breast fillets (both frozen) and chicken sausages (refrigerated) were inoculated with streptomycin-resistant (1500 μg/ml) L. monocytogenes (Brie 1) at low (ca. ~4 log10 CFU/ml) and high (ca. ~9 log10 CFU /ml) levels. Following 12 h of either frozen or refrigerated storage, random samples (n = 3 of each product) were individually microwaved for recommended time, undercooked and overcooked. Survival of L. monocytogenes after microwaving was determined by spread plating the samples and enumerating bacterial colonies on BHIA+streptomycin (1500 μg/ml). Analysis of variance with Duncans’ grouping was conducted to determine significant differences in survival (α = 0.05). Microwaving the chicken patties inoculated with high levels of bacteria for a recommended time of 1 min increased surface temperature to 64°C-74°C leading to approximately 1-log reduction (p<0.05) of L. monocytogenes. Chicken breast samples and sausages microwaved at 1100 W according to manufacturer’s instruction reduced L. monocytogenes populations below detection limit at high as well as low levels. Although, recommended microwaving times might not always be effective in eliminating L. monocytogenes, its efficacy will depend upon factors such as product type and the level of L. monocytogenes contamination. Reconstitution of RTE foods below recommended times can make them a potential source of Listeria.
References
CDC, 2002. Public health dispatch: Outbreak of Listeriosis-Northeastern United States, 2002. Morb. Mortal. Wkly. Rep., 51: 950-951.
Farbar, J.M. and P.I. Peterkin, 1991. Listeria monocytogenes, a food-borne pathogen. Microbiol. Rev., 55: 476-511.
Farber, J.M., J.Y. D'Aoust, M. Diotte, A. Sewell and E. Daley, 1998. Survival of Listeria spp. on raw whole chickens cooked in microwave ovens. J. Food Prot., 61: 1465-1469.
FAO/WHO, 2004. Hazard identification. In Risk assessment of Listeria monocytogenes in ready-to-eat foods: Technical report. Microbiological Risk Assessment Series No. 5. Food and Agriculture Organization/World Health Organization, United Nations, Switzerland, pp: 1-6.
Glass, K.A., D.A. Granberg, A.L. Smith, A.M. McNamara and M. Hardin et al., 2001. Inhibition of Listeria monocytogenes by sodium diacetate and sodium lactate on wieners and cooked bratwurst. J. Food Prot., 65: 116-123.
Gubdjornsdottir, B., M.L. Suihko, P. Gustavsson, G. Thorkelsson and S. Salo et al., 2004. The incidence of Listeria monocytogenes in meat, poultry and seafood plants in the Nordic countries. Food Microbiol., 21: 217-225.
Harrison, M.A. and S.L. Carpenter, 1989. Survival of Listeria monocytogenes on microwave cooked poultry. Food Microbiol., 6: 153-157.
Heddleson, E.A., S. Doores, R.C. Anantheswaran and G.D. Kuhn, 1996. Viability loss of Salmonella species, Staphylococcus aureus and Listeria monocytogenes in complex foods heated by microwave energy. J. Food Prot., 59: 813-818.
Heddleson, R.A. and S. Doores, 1994. Factors affecting microwave heating of foods and microwave induced destruction of food borne pathogens-A review. J. Food Prot., 57: 1025-1037.
Lado, B.H. and A.E. Yousef, 2007. Characteristics of Listeria monocytogenes Important to Food Processors. In: Listeria, Listeriosis and Food Safety, Ryser, E.T. and E.H. Marth (Eds.). 3rd Edn., CRC Press, Boca Roton, USA., ISBN: 9780824757502, pp: 157-213.
McCormick, K., I.Y. Han, J.C. Acton, B.W. Sheldon and P.L. Dawson, 2003. D and z-values for Listeria monocytogenes and Salmonella typhimurium in packaged low-fat ready-to-eat turkey bologna subjected to a surface pasteurization treatment. Poult. Sci., 82: 1337-1342.
Oliveira, M.E.C. and A.S. Franca, 2002. Microwave heating of foodstuffs. J. Food Eng., 53: 347-359.
Scallan, E., R.M. Hoekstra, F.J. Angulo, R.V. Tauxe and M.A. Widdowson et al., 2011. Foodborne illness acquired in the United States-major pathogens. Emerg. Infect. Dis., 17: 7-15.
Schwartz, B., C.V. Broome, G.R. Brown, A.W. Hightower and C.A. Ciesielski et al., 1988. Association of sporadic listeriosis with consumption of uncooked hot dogs and undercooked chicken. Lancet, 332: 779-782.
Downloads
Published
Issue
Section
License
Copyright (c) 2012 Asian Network for Scientific Information
This work is licensed under a Creative Commons Attribution 4.0 International License.
This is an open access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution and reproduction in any medium, provided the original author and source are credited.
